Browsing by Author "Davey, Christopher J."
Now showing 1 - 2 of 2
Results Per Page
Sort Options
Item Open Access Integrating crystallisation into transmembrane chemical absorption: Process intensification for ammonia separation from anaerobic digestate(Elsevier, 2020-05-15) Davey, Christopher J.; Hermassi, Mehrez; Allard, E.; Amine, M.; Sweet, N.; Schmieder Gaite, T.; McLeod, A.; McAdam, Ewan J.In this study, reactive crystallisation is introduced into a liquid-liquid membrane contactor for the selective separation, purification and recovery of ammonia from concentrated waste. Whilst liquid-liquid membrane contactor technology has been previously demonstrated for ammonia absorption, further process intensification can be achieved by incorporating crystallisation into transmembrane chemisorption to recover the ammonia as crystalline ammonium sulphate. Reactive crystallisation occurred in the draw solution (sulphuric acid) which was supplied to the lumen-side of the polypropylene hollow-fibre. The ammonium sulphate concentration in the draw solution increased through ammonia mass transfer to supersaturation, at which time induction (the onset of nucleation) commenced. Ammonia mass transfer at draw concentrations above the solubility limit was not limited provided sufficient ‘free’ sulphate was available. This resulted in nucleation which occurred at a low level of supersaturation (C/C*, 1.03) to produce small crystals of around 2.5 μm, which indicated that nucleation was favoured. The nucleation rate was found to be proportional to the ammonia flux in the draw solution. As the solution became more saturated, crystal number increased but crystal growth was comparatively small; this is symptomatic of reactive crystallisation, where the rate of reaction exceeds the rate of mass transfer. Due to the large difference in the ratio between the lumen internal diameter and the mean crystal diameter (dfibre/dmean,CSD, ∼180), no fibre clogging was observed despite facilitating crystallisation on the lumen-side of the membrane. Transmembrane chemisorption crystallisation presents a feasible process intensification for the selective separation of ammonia from environmental applications. For its integration into environmental applications, solutions to wetting and fouling remain due to associative interactions with the complex organic matrix that are practically achievable through engineering intervention. Subsequent transformation of ammonia into a crystalline phase of ammonium sulphate presents a new product which is of commercial interest.Item Open Access Membrane distillation for concentrated blackwater: Influence of configuration (air gap, direct contact, vacuum) on selectivity and water productivity(Elsevier, 2021-01-30) Davey, Christopher J.; Kamranvand, Farhad; Williams, Leon; Jiang, Ying; Parker, Alison; Tyrrel, Sean; McAdam, Ewan J.Water recovery from concentrated blackwater has been studied using air gap (AGMD), direct contact (DCMD) and vacuum membrane distillation (VMD) to deliver decentralised sanitation. Whilst good water quality was achieved with each configuration, differences in the rejection of volatile compounds was observed. VMD exhibited the highest rejection of volatiles, specifically ammoniacal nitrogen, of all the configurations but fouling inhibited total flux. DCMD exhibited a temperature dependent volatile rejection which resulted in poor rejection at lower feed temperatures (≤40 °C). AGMD was identified as the most promising configuration for application within decentralised sanitation, since the rejection of volatiles was consistent over a range of operating temperatures with ammonia rejection directly related to solution pH. An increase in organic colloids and particles due to faecal contamination reduced COD removal due to the induction of wetting, but was shown to be offset by adoption of a smaller pore size (0.1 μm), and when complemented with upstream solid-liquid separation within a fully integrated system, will provide a robust sanitation solution. Importantly, this work has shown that AGMD can recover water from concentrated blackwater close to international discharge and reuse regulations in a single stage process; this is significant as blackwater consists of only urine and faeces, and is thus 40 times more concentrated than municipal sewage. It is proposed that the water quality produced reflects a step change to delivering safe sanitation, and is complemented by a simple method for heat recovery integration this is similarly advantageous for resource constrained environments common to decentralised sanitation solutions.